Electrodialytic extraction of Cu,Pb and Cl from municipal solid waste incineration fly ash suspended in water

The possibility of using fly ash from municipal solid waste incineration (MSWI) in, for example, concrete is considered. MSWI fly ash, however, has too high a concentration of heavy metals, which may cause leaching problems during use or problems with waste handling at the end of the lifetime of the concrete. The Cl content in MSWI fly ash is also too high and will cause corrosion problems in reinforced concrete. The possibility of removing some of the unwanted heavy metals (Cu and Pb) together with Cl from an MSWI fly ash suspended in water using an electrodialytic separation method was investigated. The removal of Pb and Cu was found to be highly pH dependent and the highest contents removed were 41 and 90%, respectively. The Cu concentration of the ash decreased from 2200 to 860 mg kg^?1 but the Pb concentration increased from 8560 to 16 800 mg kg^?1, showing that Pb is mainly found in the ash fraction that is least soluble. Hence electrodialytic treatment of the ash suspended in water is not a solution to improve the ash quality in terms of Pb. The water‐soluble Cl content per unit weight of the original ash was 12.4%. The removal of water‐soluble Cl was efficient and >98% of Cl was removed (calculated on the basis of mean initial and final concentrations). This result indicates that electrodialytic extraction may be a method that can be used for the removal of Cl from ash prior to its utilization in concrete. Copyright © 2006 Society of Chemical Industry     

新型环氧防腐涂料的研究

采用在环氧树脂中加入纳米复合铁钛粉防锈颜料WD—D-325、固化剂、制备了新型环氧树脂防腐涂料。由于纳米技术的特性，该防腐涂料具有较高的防腐性、优异的附着力和柔韧性。实验确定了复合铁钛粉防锈颜料在环氧防腐涂料中的添加量。作为新型的环保颜料，复合铁钛粉防锈颜料可以替代红丹、锌铬黄等颜料。     

An apparent ensemble effect in the oxidative coupling of methane on hydroxyapatites with incorporated lead

The introduction of small quantities of lead into calcium hydroxyapatite catalysts produces marked increases in the selectivity to C₂₊ hydrocarbons, while the conversion of methane remains relatively constant. Small surface concentrations of lead are sufficient to achieve C₂₊ selectivities of 80 and 90%, with oxygen and nitrous oxide, respectively, in contrast with 18 and 46%, respectively, obtained in the absence of lead. Since surface concentration of lead species sufficient to stabilize pairs of methyl radicals in close proximity to each other would be expected to facilitate the formation of C₂ hydrocarbons, an ensemble effect appears to be extant.     

氧化铁覆膜滤沙对陶瓷化工厂废水中铅吸附性能的研究

用合成方法制备氧化铁覆膜滤沙。在动态条件下,研究了氧化铁覆膜滤沙对重金属离子Pb2 的吸附效果及吸附条件。含Pb2 的陶瓷化工厂废水经氧化铁覆膜滤沙吸附后,Pb2 离子含量显著低于国家排放标准。     

水泥企业常用热电偶的使用与维护

测温元件——热电偶热的电势大小仅和两金属的材料及两结合点的温度有关．鉴于此因素．适当的维护和维修可延长其使用寿命，减少生产成本。针对不同测量系统和不同工艺要求，介绍了四种水泥企业最常用的热电偶以及安装热电偶时所需注意事项。根据生产实践，重点介绍了热电偶的常见故障及其维护与维修方法。     

铅锌烧结烟气制酸装置的技术改造

介绍白银有色金属集团有限责任公司第三冶炼厂总设计能力为70kt/a的两套铅锌烧结机烟气制酸装置的特点、存在问题及技术改造。通过改造，硫酸产量逐年递增，至2002年达到78．3kt，创造了良好的经济和环境效益。     

Synthesis and Microstructure of Highly Oriented Lead Titanate Thin Films Prepared by a Sol-Gel Method

Thin films of PbTiO₃ were deposited on fused silica, resistor-grade alumina, and single-crystal (100) MgO by a sol–gel processing method. Whereas the films deposited on silica and alumina substrates were randomly oriented and polycrystalline, highly {100} oriented PbTiO₃ films were grown on the MgO single crystals. The perovskite-type structure was observed with films deposited on the single-crystal MgO and annealed at temperatures as low as 470°C, whereas a pyrochlore-type strcuture was observed with films on fused silica and alumina processed in a similar manner. All films heat-treated at temperatures in excess of 570°C showed significant formation of a second PbTi₃O₇ phase. The films were characterized by electron microscopy and glancing-incidence-angle X-ray diffraction.     

一种新型吸附剂在痕量重金属分析中的应用

以二苯并18-冠-6交联席夫碱型壳聚糖作为新型吸附剂，用石墨炉原子吸收分光光度法测定了经过滤处理后的燃煤烟气中痕量铬、镉和铅的含量。经过滤处理后的燃煤烟气含铬1．42／μg／m3，其中三价铬占54．20％，为0．77μg／m3，镉0．256μg／m3，铅5．30μg/m3。     

Pb、Bi连续测定综合实验设计

对Pb、Bi连续测定中的Pb、Bi废液采用Na2S沉淀,HNO3溶解后配制成分析溶液,将原来的分析实验设计成集回收和测定于一体的综合实验,使Pb、Bi溶液可以循环利用,解决了废液排放造成的Pb污染和试剂消耗,实现了化学实验的绿色化,达到了综合训练的目的。